How should headlights be adjusted on Volkswagen Passat?

Some models are equipped with a headlight leveling system, and the adjustment procedure will not apply; therefore, have the headlights adjusted by a dealer service department or other qualified repair shop. These models feature headlight housings with two adjustment screws, one for left-and-right movement and another for up-and-down movement. Several methods exist for adjusting the headlights, with the simplest requiring an open area, a blank wall, and a level floor. Position masking tape vertically on the wall in line with the vehicle centerline and the centerlines of both headlights, and place a horizontal tape line in line with the centerline of all the headlights; it may be easier to position the tape with the vehicle parked just a few inches away. Adjustments should be made with the vehicle parked 25 feet from the wall, sitting level, with the gas tank half-full and no unusually heavy load. For low beam adjustment, position the high intensity zone two inches below the horizontal line and two inches to the side of the vertical headlight line, away from oncoming traffic, twisting the adjustment screws until the desired level is achieved. With the high beams on, the high intensity zone should be vertically centered with the exact center just below the horizontal line; it may not be possible to position the headlight aim exactly for both high and low beams, so if a compromise is necessary, prioritize the low beams, as they are most used and significantly impact driver safety. Have the headlights adjusted by a dealer service department at the earliest opportunity.

How to replace the headlight housing on Volkswagen Passat?

On 2001 and older models, the first step is to take the housing of the front turn signal off, and use masking tape to cover the area around the headlight housing to cover the body. Then remove the covers and screwdriver the mounting screws of the headlight housing out. Gently lift the headlight housing forward and a little sideways, loosening the front grille trim, remove the electrical connectors, and pull the housing all the way out. Installation is opposite of this: To install, slide the housing back in and make sure the grille tabs fit on one side of the other and reconnect the electrical connections inside the engine compartment and and install in the same sequence. In 2002s and subsequent models, begin by unattachment of front bumper cover and the piece of plastic reinforcing it, thereafter, disconnect the wiring to the headlight. Removal of the cover headlight bolt should be done by peeling the cover then removed which is the other two headlight mounting bolts. Move the headlight housing out of the car and forward, and then install it on the reverse of the take out procedure.

Genuine Volkswagen Passat Headlight

Headlamp

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

32 Headlights found

View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3B0-941-018-Q
$166.01 MSRP: $232.49
You Save: $66.48 (29%)
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Right
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 1998-2001 Volkswagen Passat | 4 Motion, GLS, GLS 4 Motion, GLX, GLX 4 Motion | 4 Cyl 1.8 L GAS, 6 Cyl 2.8 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3B0-941-017-Q
$180.12 MSRP: $252.26
You Save: $72.14 (29%)
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Left
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 1998-2001 Volkswagen Passat | 4 Motion, GLS, GLS 4 Motion, GLX, GLX 4 Motion | 4 Cyl 1.8 L GAS, 6 Cyl 2.8 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3B0-941-015-AQ
$185.84 MSRP: $260.28
You Save: $74.44 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Left
- Replaces: 3B0-941-015-AM
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2001-2005 Volkswagen Passat | GL, GL TDI, GLS, GLS 4 Motion, GLS TDI, GLX, GLX 4 Motion, W8 | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 6 Cyl 2.8 L GAS, 8 Cyl 4.0 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3B0-941-016-AQ
$185.84 MSRP: $260.28
You Save: $74.44 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Right
- Replaces: 3B0-941-016-AM
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2001-2005 Volkswagen Passat | GL, GL TDI, GLS, GLS 4 Motion, GLS TDI, GLX, GLX 4 Motion, W8 | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 6 Cyl 2.8 L GAS, 8 Cyl 4.0 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-005-D
$214.30 MSRP: $300.13
You Save: $85.83 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Left
- Replaces: 561-941-005-A, 561-941-005-B
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2012-2015 Volkswagen Passat | Limited Edition, S, SE, SEL, SEL Premium, Sport, TDI SE, TDI SEL, TDI SEL Premium, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 5 Cyl 2.5 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-006-D
$221.61 MSRP: $310.39
You Save: $88.78 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Right
- Replaces: 561-941-006-A, 561-941-006-B
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2012-2015 Volkswagen Passat | Limited Edition, S, SE, SEL, SEL Premium, Sport, TDI SE, TDI SEL, TDI SEL Premium, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 5 Cyl 2.5 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-006-F
$267.16 MSRP: $364.97
You Save: $97.81 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Composite Assembly, Headlamp Assembly
- Position: Right
- Replaces: 561-941-006-E
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2016-2019 Volkswagen Passat | GT, R-Line, S, SE, SE R-Line, SEL, SEL Premium, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3C0-941-005-AE
$256.20 MSRP: $350.00
You Save: $93.80 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Left
- Replaces: 3C0-941-005-P, 3C0-941-005-L
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2006-2010 Volkswagen Passat | 2.0T, 3.6, Komfort, Lux, Turbo, Value Edition, VR6, Wolfsburg Edition | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3C0-941-006-AE
$256.20 MSRP: $350.00
You Save: $93.80 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Right
- Replaces: 3C0-941-006-P, 3C0-941-006-L
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2006-2010 Volkswagen Passat | 2.0T, 3.6, Komfort, Lux, Turbo, Value Edition, VR6, Wolfsburg Edition | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-005-F
$258.76 MSRP: $353.50
You Save: $94.74 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Composite Assembly, Headlamp Assembly
- Position: Left
- Replaces: 561-941-005-E
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2016-2019 Volkswagen Passat | GT, R-Line, S, SE, SE R-Line, SEL, SEL Premium, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3B7-941-017-T
$362.12 MSRP: $494.70
You Save: $132.58 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Left
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2003-2005 Volkswagen Passat | GL, GL TDI, GLS, GLS 4 Motion, GLS TDI, GLX, GLX 4 Motion, W8 | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 6 Cyl 2.8 L GAS, 8 Cyl 4.0 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3B7-941-018-T
$423.94 MSRP: $579.15
You Save: $155.21 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Right
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2003-2005 Volkswagen Passat | GL, GL TDI, GLS, GLS 4 Motion, GLS TDI, GLX, GLX 4 Motion, W8 | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 6 Cyl 2.8 L GAS, 8 Cyl 4.0 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3C0-941-754-J
$582.21 MSRP: $795.37
You Save: $213.16 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Right
- Replaces: 3C0-941-754-C, 3C0-941-754-F
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2006-2008 Volkswagen Passat | 2.0T, 3.6, Komfort, Lux, Turbo, Value Edition, VR6, Wolfsburg Edition | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3C0-941-754-M
$594.74 MSRP: $812.49
You Save: $217.75 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Composite Assembly
- Position: Right
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2008-2010 Volkswagen Passat | Komfort, Lux, Turbo, VR6 | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3C0-941-753-M
$652.69 MSRP: $891.65
You Save: $238.96 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Composite Assembly
- Position: Left
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2008-2010 Volkswagen Passat | Komfort, Lux, Turbo, VR6 | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 3C0-941-753-J
$606.93 MSRP: $829.16
You Save: $222.23 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp; Headlamp Assembly
- Position: Left
- Replaces: 3C0-941-753-F, 3C0-941-753-C
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2006-2008 Volkswagen Passat | 2.0T, 3.6, Komfort, Lux, Turbo, Value Edition, VR6, Wolfsburg Edition | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-774-A
$750.25 MSRP: $1024.94
You Save: $274.69 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlight; Composite Assembly
- Position: Right
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2016-2019 Volkswagen Passat | GT, R-Line, S, SE, SE R-Line, SEL, SEL Premium, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-773-A
$799.22 MSRP: $1091.82
You Save: $292.60 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlight; Composite Assembly
- Position: Left
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2016-2019 Volkswagen Passat | GT, R-Line, S, SE, SE R-Line, SEL, SEL Premium, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-035-B
$881.74 MSRP: $1204.56
You Save: $322.82 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlight; Composite Assembly, Headlamp Assembly
- Position: Left
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2020-2022 Volkswagen Passat | Limited Edition, R-Line, S, SE, SEL | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Passat Headlamp Assembly Part Number: 561-941-082-A
$961.51 MSRP: $1313.54
You Save: $352.03 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlight
- Warranty: This genuine part is guaranteed by Volkswagen's factory warranty.
Fits the following Vehicles:
- 2020-2022 Volkswagen Passat | Limited Edition, R-Line, S, SE, SEL | 4 Cyl 2.0 L GAS

| Page 1 of 2 |Next >

1-20 of 32 Results

Volkswagen Passat Headlight

The Volkswagen Passat Headlight is basically there to ensure that drivers can see and be seen at night after dusk, making any night trip safe. Every Headlight style embraced throughout the years serves that mission in a somewhat varied manner, from early halogen reflectors to projector lamps with focused beams that reach further. The Volkswagen system of lighting has become more diverse, with factory options now extending to LED clusters, which consume less current but are very bright, and fancy halo rings or daytime running light bars, which do not alter fundamental mounting. All the versions are similar in that they change electrical energy into a focused pattern that illuminates the lane ahead and keeps the glare out of oncoming traffic. The aim can be easily altered by the driver with the help of two screws below the hood; one of them can be turned vertically and the other horizontally, which allows adjustment without causing blindness to other drivers by putting the lamps too high. The timing of replacement depends on usage; therefore, observable dimming is an indication that it is time to change a bulb in any Passat after 1995, and this is not supposed to be complicated but should take a short period of time, and the tools required should be light. Amateurs can also upgrade to a higher-wattage halogen, HID capsules, or higher-power LEDs with superior light and a longer lifespan, assuming such an increase is not illegal in their area. Typical components retain the unifying styling that makes a Volkswagen, maintain prices lower than dealer parts, and make sure that the hard-working Headlight still protects the road ahead on every contemporary Volkswagen trip.

Choose OEM Headlight for superior quality and long-lasting durability. They match the Volkswagen's factory specifications exactly and pass strict quality control. If you plan to replace Headlight on your Passat, put OEM at the top of your list. You'll get the right fit, reliable performance, and peace of mind. We stock an extensive inventory of genuine Volkswagen Passat parts. It is easy to find what you need. You will love our competitive prices that help you save. No more hassle with returns or guesswork. Every part includes a warranty straight from the manufacturer. Get trusted quality, strong durability, and real value today.

Volkswagen Passat Headlight Parts and Q&A

Headlamp Assembly
3B0-941-016-AQ
Q: How should headlights be adjusted on Volkswagen Passat?
A:
Some models are equipped with a headlight leveling system, and the adjustment procedure will not apply; therefore, have the headlights adjusted by a dealer service department or other qualified repair shop. These models feature headlight housings with two adjustment screws, one for left-and-right movement and another for up-and-down movement. Several methods exist for adjusting the headlights, with the simplest requiring an open area, a blank wall, and a level floor. Position masking tape vertically on the wall in line with the vehicle centerline and the centerlines of both headlights, and place a horizontal tape line in line with the centerline of all the headlights; it may be easier to position the tape with the vehicle parked just a few inches away. Adjustments should be made with the vehicle parked 25 feet from the wall, sitting level, with the gas tank half-full and no unusually heavy load. For low beam adjustment, position the high intensity zone two inches below the horizontal line and two inches to the side of the vertical headlight line, away from oncoming traffic, twisting the adjustment screws until the desired level is achieved. With the high beams on, the high intensity zone should be vertically centered with the exact center just below the horizontal line; it may not be possible to position the headlight aim exactly for both high and low beams, so if a compromise is necessary, prioritize the low beams, as they are most used and significantly impact driver safety. Have the headlights adjusted by a dealer service department at the earliest opportunity.
Headlamp Assembly
3B0-941-015-AQ
Q: How to replace the headlight housing on Volkswagen Passat?
A:
On 2001 and older models, the first step is to take the housing of the front turn signal off, and use masking tape to cover the area around the headlight housing to cover the body. Then remove the covers and screwdriver the mounting screws of the headlight housing out. Gently lift the headlight housing forward and a little sideways, loosening the front grille trim, remove the electrical connectors, and pull the housing all the way out. Installation is opposite of this: To install, slide the housing back in and make sure the grille tabs fit on one side of the other and reconnect the electrical connections inside the engine compartment and and install in the same sequence. In 2002s and subsequent models, begin by unattachment of front bumper cover and the piece of plastic reinforcing it, thereafter, disconnect the wiring to the headlight. Removal of the cover headlight bolt should be done by peeling the cover then removed which is the other two headlight mounting bolts. Move the headlight housing out of the car and forward, and then install it on the reverse of the take out procedure.