How to properly discharge and replace the A/C condenser on Volkswagen Jetta?

Start with emptying the air conditioning system. Lift up the car and place it on jackstands. Take off splashing shield at the under-vehicle, when fitted. Coolant in the radiator should be drained (recycled where it is new); used antifreeze should be handled carefully. disassemble the bumper with front, cooling fan shroud, radiator. Unscrew the air duct retaining tabs and take out the air ducts of the side of the condenser. Unscrew the suction and discharge line attachments of the right side of the condenser, use a plug in the exposed fittings to avoid intrusion of dirt and moisture, and remove the seals between the plates and condenser. Should there be a charge air system circuit cooler, slide it until the upper mounts are clear, and then remove it and store out of the workspace. Unscrew the fasteners of the condenser, tip the top of the condenser backwards and extract it. To install, revert the removal procedure whereby new O-rings are used on the air conditioning system fittings. In case of a new condenser installation, place new refrigerant oil, which matches the system. Fill the system and bleed the system and then start the engine to test whether there are leaks. Lastly, the shop which released the system should evacuate, recharge and leak-test the system.

How to properly discharge and replace the A/C condenser on Volkswagen Passat?

Start with emptying the air conditioning system. Lift the car and place it on jackstands. Take off splash shield below engine where it has one fitted. Removal of the front bumper assembly. Unfasten the line of power steering oil cooler off the radiator support panel and lay it aside. Disassemble the A/C pressure switch, as well as, the condenser inlet and outlet lines. Open the condenser holding pins, and pull the condenser off the radiator pushing the center pin over, then pulling the retaining pin out, being careful not to lose one of the retaining pins which are positioned on each side. The process of installation is in the reverse direction of removal with new O-rings being used in the fittings of the air conditioning system. Should the replacement be on the condenser, use fresh refrigerant oil to the new condenser and make sure that it is R-134a compatible. Lastly, have the system emptied, refilled, and checked by a service department of a dealer or automotive air conditioning repair shop.

Genuine Volkswagen A/C Condenser

Air Conditioning Condenser

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

51 A/C Condensers found

View related parts
Volkswagen Condenser Part Number: 1HM-820-413-B
$149.38 MSRP: $209.22
You Save: $59.84 (29%)
ADD TO CART
Fits the following Volkswagen Models:
- Cabrio | 1995-2002 | Base, GL, GLS, GLX, High Line | 4 Cyl 2.0 L GAS
- Golf | 1993-1999 | Celebration Edition, City, GL, GTI, GTI VR6, Jazz, K2, Limited Edition, Sport, Trek, Wolfsburg Edition | 4 Cyl 1.9 L DIESEL, 4 Cyl 2.0 L GAS, 6 Cyl 2.8 L GAS
- Jetta | 1993-1999 | Celebration Edition, City, GL, GLS, GLX, GT, Jazz, K2, Limited Edition, TDI, Trek, Wolfsburg Edition | 4 Cyl 1.9 L DIESEL, 4 Cyl 2.0 L GAS, 6 Cyl 2.8 L GAS
View More
View related parts
Volkswagen Condenser Part Number: 1K0-820-411-Q
$178.50 MSRP: $250.00
You Save: $71.50 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 1K0-820-411-H, 1K0-820-411-D, 1K0-820-411-P, 5M0-298-403, 1K0-820-411-J
Fits the following Volkswagen Models:
- Eos | 2007-2016 | 2.0T, 3.2, Base, Executive, Final Edition, Komfort, Lux, Sport, Turbo, VR6 | 4 Cyl 2.0 L GAS, 6 Cyl 3.2 L GAS
- GTI | 2006-2014 | Base, Driver's Edition, Fahrenheit, Wolfsburg Edition | 4 Cyl 2.0 L GAS
- Golf | 2010-2014 | Base, TDI | 4 Cyl 2.0 L DIESEL, 5 Cyl 2.5 L GAS
- Golf R | 2012-2013 | Base | 4 Cyl 2.0 L GAS
- Jetta | 2005-2014 | 2.0T, 2.5, GL, GL TDI, GLI, GLS, GLS TDI, S, SE, SEL, TDI, TDI Cup Edition, Value Edition, Wolfsburg Edition | 4 Cyl 1.9 L DIESEL, 4 Cyl 2.0 L DIESEL, 4 Cyl 2.0 L GAS, 5 Cyl 2.5 L GAS
- R32 | 2008 | Base | 6 Cyl 3.2 L GAS
- Rabbit | 2006-2009 | 2.5, S | 5 Cyl 2.5 L GAS
View More
View related parts
Volkswagen Condenser Part Number: 5QM-816-411-D
$197.41 MSRP: $276.49
You Save: $79.08 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaced by: 5QM-816-411-E
Fits the following Volkswagen Models:
- Jetta | 2024 | GLI Autobahn, S, SE, SEL, Sport | 4 Cyl 1.5 L GAS, 4 Cyl 2.0 L GAS
- Taos | 2024 | S, SE, SEL | 4 Cyl 1.5 L GAS
View related parts
Volkswagen Condenser Part Number: 1H0-820-413
$209.19 MSRP: $292.98
You Save: $83.79 (29%)
ADD TO CART
Fits the following Volkswagen Models:
- Cabrio | 1995-1997 | Base, High Line | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 1K0-820-411-AH
$219.90 MSRP: $307.99
You Save: $88.09 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Refriger.Condenser.
Fits the following Volkswagen Models:
- Eos | 2016 | Komfort | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 3D0-820-411-G
$295.47 MSRP: $403.65
You Save: $108.18 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 3D0-820-411-E
Fits the following Volkswagen Models:
- Phaeton | 2004-2006 | V8, W12 | 12 Cyl 6.0 L GAS, 8 Cyl 4.2 L GAS
View related parts
Volkswagen Condenser Part Number: 3B0-260-401-B
$224.55 MSRP: $314.50
You Save: $89.95 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 3B0-260-401-A
Fits the following Volkswagen Models:
- Passat | 2001-2005 | GL, GL TDI, GLS, GLS 4 Motion, GLS TDI, GLX, GLX 4 Motion | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 6 Cyl 2.8 L GAS
View related parts
Volkswagen Condenser Part Number: 5N0-820-411-E
$252.34 MSRP: $344.74
You Save: $92.40 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 5N0-820-411-D, 5N0-820-411-C
Fits the following Volkswagen Models:
- Tiguan | 2009-2017 | R-Line, S, SE, SEL, Sport, Wolfsburg Edition | 4 Cyl 2.0 L GAS
- Tiguan Limited | 2017-2018 | Base | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 3B7-260-403-A
$235.62 MSRP: $330.00
You Save: $94.38 (29%)
Ships in 1-2 Business Days
ADD TO CART
Fits the following Volkswagen Models:
- Passat | 2002-2004 | W8 | 8 Cyl 4.0 L GAS
View related parts
Volkswagen Condenser Part Number: 1C0-820-413-G
$236.69 MSRP: $331.50
You Save: $94.81 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 1C0-820-413-A, 1C0-820-413-E
Fits the following Volkswagen Models:
- Beetle | 1998-2006 | Base, GL, GLS, GLS TDI, GLX, Sport, TDI, Turbo S | 4 Cyl 1.8 L GAS, 4 Cyl 1.9 L DIESEL, 4 Cyl 2.0 L GAS
- Corrado | 1994 | SLC | 6 Cyl 2.8 L GAS
View related parts
Volkswagen Condenser Part Number: 3C0-820-411-D
$254.91 MSRP: $348.23
You Save: $93.32 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 3C0-820-411-B
Fits the following Volkswagen Models:
- CC | 2009-2016 | 4 Motion, Executive, Executive 4 Motion, Lux, V6 Executive 4Motion, VR6, VR6 4Motion, VR6 4Motion Executive, VR6 Sport | 6 Cyl 3.6 L GAS
- Passat | 2006-2010 | 2.0T, 3.6, Komfort, Lux, Turbo, Value Edition, VR6, Wolfsburg Edition | 4 Cyl 2.0 L GAS, 6 Cyl 3.6 L GAS
View related parts
Volkswagen Condenser Part Number: 1EA-816-411-A
$259.38 MSRP: $354.35
You Save: $94.97 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Refriger.Condenser.
Fits the following Volkswagen Models:
- ID.4 | 2021-2023 | 1st Edition, Pro, Pro S, Pro S Plus, S, Standard | BATTERY EV (EV/BEV)
View related parts
Volkswagen Condenser Part Number: 1J0-820-413-N
$262.59 MSRP: $358.73
You Save: $96.14 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaces: 1J0-820-413-D, 1J0-820-413-L
Fits the following Volkswagen Models:
- Golf | 1999-2006 | GL, GL TDI, GLS, GLS TDI, GTI, GTI 1.8T, GTI 20th Anniversary, GTI 337, GTI GLS, GTI GLX, GTI VR6, TDI, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 1.9 L DIESEL, 4 Cyl 2.0 L GAS, 6 Cyl 2.8 L GAS
- Jetta | 1999-2005 | GL, GL TDI, GLI, GLS, GLS TDI, GLX, TDI, Wolfsburg Edition | 4 Cyl 1.8 L GAS, 4 Cyl 1.9 L DIESEL, 4 Cyl 2.0 L GAS, 6 Cyl 2.8 L GAS
- R32 | 2004 | Base | 6 Cyl 3.2 L GAS
View More
View related parts
Volkswagen Condenser Part Number: 5Q0-816-411-AR
$262.59 MSRP: $358.73
You Save: $96.14 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Condenser Assembly
- Replaces: 5Q0-816-411-AB, 5Q0-816-411-AP
Fits the following Volkswagen Models:
- Arteon | 2019-2023 | SE, SE R-Line, SEL, SEL Premium, SEL Premium R-Line, SEL R-Line | 4 Cyl 2.0 L GAS
- GTI | 2015 | Autobahn, S, SE | 4 Cyl 2.0 L GAS
- Jetta | 2019-2024 | GLI 35th Anniversary Edition, GLI Autobahn, GLI S, R-Line, S, SE, SEL, SEL Premium, Sport | 4 Cyl 1.4 L GAS, 4 Cyl 1.5 L GAS, 4 Cyl 2.0 L GAS
- Taos | 2022-2024 | S, SE, SEL | 4 Cyl 1.5 L GAS
View More
View related parts
Volkswagen Condenser Part Number: 5Q0-816-411-BF
$262.59 MSRP: $358.73
You Save: $96.14 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaced by: 5Q0-816-411-BE
- Replaces: 5Q0-816-411-AN
Fits the following Volkswagen Models:
- Golf R | 2015-2019 | Base | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 3C0-820-411-F
$265.79 MSRP: $363.11
You Save: $97.32 (27%)
Ships in 1-2 Business Days
ADD TO CART
Fits the following Volkswagen Models:
- CC | 2009-2017 | Executive, Lux, Lux Limited, Lux Plus, Luxury, R-Line, R-Line Executive, Sport, Sport Plus, Trend | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 561-816-411
$265.79 MSRP: $363.11
You Save: $97.32 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Condenser Assembly
- Replaced by: 3C0-820-411-F
Fits the following Volkswagen Models:
- Passat | 2020-2022 | Limited Edition, R-Line, S, SE, SEL | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 5WA-816-411-A
$269.00 MSRP: $367.49
You Save: $98.49 (27%)
Ships in 1-2 Business Days
ADD TO CART
Fits the following Volkswagen Models:
- GTI | 2022-2024 | 40th Anniversary Edition, Autobahn, S, SE | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 5WA-816-411-D
$269.00 MSRP: $367.49
You Save: $98.49 (27%)
Ships in 1-2 Business Days
ADD TO CART
Fits the following Volkswagen Models:
- GTI | 2022 | Autobahn, S, SE | 4 Cyl 2.0 L GAS
- Golf R | 2022-2023 | 20th Anniversary Edition, Base | 4 Cyl 2.0 L GAS
View related parts
Volkswagen Condenser Part Number: 5C0-816-411
$275.40 MSRP: $376.24
You Save: $100.84 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Condenser Assembly
- Replaces: 5C0-820-411-F, 5C0-820-411-G, 5C0-820-411, 5C0-820-411-E
Fits the following Volkswagen Models:
- Beetle | 2017-2019, 2012-2015 | #PinkBeetle, Base, Classic, Coast, Dune, Final Edition SE, Final Edition SEL, Fleet Edition, GSR, R-Line, R-Line SEL, S, SE, SEL, TDI, Turbo | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 4 Cyl 2.0 L GAS, 5 Cyl 2.5 L GAS
- Jetta | 2011-2015 | Base, GLI, GLI SE, GLI SEL, Hybrid, Hybrid SE, Hybrid SEL, Hybrid SEL Premium, S, SE, SEL, Sport, TDI, TDI Premium, TDI S, TDI SE, TDI SEL | 4 Cyl 1.4 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L DIESEL, 4 Cyl 2.0 L GAS, 5 Cyl 2.5 L GAS

| Page 1 of 3 |Next >

1-20 of 51 Results

Volkswagen A/C Condenser

A total system failure could result from a malfunctioning Volkswagen A/C Condenser, reducing driving comfort and posing a danger. It is for this reason that you should conduct regular inspections and replace such components in good time to enable your car to run smoothly and safely. OEM (Original Equipment Manufacturer) Volkswagen A/C Condensers are perfect for motorists because they are the best quality parts produced as per the manufacturer's specifications; hence, they perform well and are reliable too, thus helping to retain the car's initial functionality as well as safety features. At VWPartsGiant.com, our genuine Volkswagen A/C Condenser supply indicates how much we care about the health of your vehicle. Additionally, our stock is vast, so every product will be easily accessible to you for finding and swapping without fear of making mistakes. With our user-friendly online catalog, it takes no time to identify the right spare part. Therefore, convenience accompanies servicing or maintaining a motorcar. You can rely on our OEM Volkswagen A/C Condenser to sustain the performance of your automobile.

Volkswagen A/C Condenser Parts and Q&A

Condenser
1K0-820-411-Q
Q: How to properly discharge and replace the A/C condenser on Volkswagen Jetta?
A:
Start with emptying the air conditioning system. Lift up the car and place it on jackstands. Take off splashing shield at the under-vehicle, when fitted. Coolant in the radiator should be drained (recycled where it is new); used antifreeze should be handled carefully. disassemble the bumper with front, cooling fan shroud, radiator. Unscrew the air duct retaining tabs and take out the air ducts of the side of the condenser. Unscrew the suction and discharge line attachments of the right side of the condenser, use a plug in the exposed fittings to avoid intrusion of dirt and moisture, and remove the seals between the plates and condenser. Should there be a charge air system circuit cooler, slide it until the upper mounts are clear, and then remove it and store out of the workspace. Unscrew the fasteners of the condenser, tip the top of the condenser backwards and extract it. To install, revert the removal procedure whereby new O-rings are used on the air conditioning system fittings. In case of a new condenser installation, place new refrigerant oil, which matches the system. Fill the system and bleed the system and then start the engine to test whether there are leaks. Lastly, the shop which released the system should evacuate, recharge and leak-test the system.
Condenser
3B0-260-401-B
Q: How to properly discharge and replace the A/C condenser on Volkswagen Passat?
A:
Start with emptying the air conditioning system. Lift the car and place it on jackstands. Take off splash shield below engine where it has one fitted. Removal of the front bumper assembly. Unfasten the line of power steering oil cooler off the radiator support panel and lay it aside. Disassemble the A/C pressure switch, as well as, the condenser inlet and outlet lines. Open the condenser holding pins, and pull the condenser off the radiator pushing the center pin over, then pulling the retaining pin out, being careful not to lose one of the retaining pins which are positioned on each side. The process of installation is in the reverse direction of removal with new O-rings being used in the fittings of the air conditioning system. Should the replacement be on the condenser, use fresh refrigerant oil to the new condenser and make sure that it is R-134a compatible. Lastly, have the system emptied, refilled, and checked by a service department of a dealer or automotive air conditioning repair shop.